Cooling bandanas are super easy to make. If you can sew a straight or almost straight line you can do it! It might be snowing outside today, but summer will be here soon enough and you want to be ready.
I found my bandanas for a dollar each, and since you only need 1-1 1/2 tsp. crystals per bandana, these are super budget friendly. I’ve seen these sold at summer fairs for up to ten bucks each. But, on a hot day in August at the rib cook off, I almost paid it to cool off!
Start by folding your bandana in half crosswise. Right sides facing each other. Mark a spot 6 inches back from each point. This is where you will make the casing for the crystals. I used a pin on each end to mark.
You want to sew from the folded side down 1 1/2 inches from the edge, stop with your needle down in the fabric. Lift the pressure foot and turn the fabric to sew along the long side. Sew down to your second mark but don’t turn. You need to leave this open to put in the crystals. Remove from your machine, and clip your threads. You’ve just made a pocket (tube) to hold the “magic” crystals.
Use a measuring spoon to scoop 1/4- 1/2 tsp. of crystals and pour into the opening you just created. Be sure to keep the crystals away from children and pets, they’re highly toxic! Shake them down to the end of the tube. I suggest you split up this tube into four sections so all the crystals don’t bunch into one clump. Sew a line across the pocket about 3-4 inches from the end to keep those crystals there. Repeat this 3 more times for a total of four pockets. They only need to be measured if your OCD is acting up, otherwise just eyeball it. When you close the final pocket, double stitch it, and continue down the long side and finish a double line at the other end.
Now flip the bandana open, right sides out, crystal pockets inside, and stitch along the edge of the pockets over again. This puts a double layer of fabric over the crystals, and hides any boo boos.
You can get fancy with your sewing machine and use a decorative top stitch. I was working on quantity, so plain straight stitch for these.
To use them, just soak in cold water 2-3 hours (try it overnight in the fridge). They can be stored wet in a ziplock bag, or let them dry out completely when not in use. Good to keep a couple in your vehicle or RV. Great for hiking, biking or anytime the heat is on!